鋁合金免烘烤油墨鋁合金耐酒精油墨1、油墨特性：低氣味，高光澤，色澤鮮艷，遮蓋力強，耐酒精，耐汽油，抗腐蝕。2、適用材料：主要應用于各種五金、鋁合金、不銹鋼、氧化鋁、白鐵電鍍、PP材料。3、技術參數：a. 粘度：8000—12000CPS；b. 細度：5UM↓ 、光澤：60°↑ ；c. 干燥條件：65℃—70℃，25min  自干24小時d. 鉛筆硬度：2H↑ ；e. 耐鹽務性：24H；f. 耐酒精：99％乙醇500g力來回30次；g. 耐磨：500g力來回超過30次；h. 過網性：77T—145T網紗〔金、銀粉調配顏色除外〕4、稀釋劑的選擇：稀釋劑：S—783：便用前添加13％—15％的DB—01固化劑。5、注意事項：a.使用前將油墨與固化劑攪拌均勻，用后4個小時后須更換新的油墨,以便出現干網,和固化劑凝固!b.根據需要可添加15％—20％的稀釋劑進行稀釋?zhuān)籧.施工件在施工前清除表面油漬及污物；d.需多色套印時應等前面的顏色表干后進行套色；e.在作測試時應先讓墨層完全干燥；      d.不得將油墨與其它油墨混合及配色，添加固化劑后，效果會大大的改善，若加固化劑后請將油墨在4小時用完。6、應急處理措施：a.如浸濺到眼部立即清水清洗，嚴重者就醫。b.滅火急救措施：用干粉，泡沫滅火器或沙子滅火?！鶄渥ⅲ河捎诓牧霞笆褂弥械淖償?shù)，可能是結果會有變化，以上數據僅供參考，使用前請自行測試。 1, ink characteristics: low odor, high gloss, bright color, hiding power, alcohol, gasoline, corrosion resistance.2, applicable materials: mainly used in all kinds of hardware, Aluminum Alloy, stainless steel, aluminum, tin plating, PP material.3, technical parameters:A. viscosity: 8000 - 12000CPS;B.: 5UM:: gloss, fineness of 60 degrees up;C. drying conditions: 65 DEG C - 70 DEG C, 25min dry for 24 hoursD. pencil hardness: 2H up;Salt resistance: 24H e.;F. alcohol resistance: 99% ethanol 500g force back and forth 30 times;G. wear: 500g force back and forth more than 30 times;H. network: 77T - 145T Jacobs, except gold and silver powder colors.4, diluent choice: diluent: S - 783: before use, add 13% - 15% of DB - 01 curing agent.5, matters needing attention:A. use before the ink and curing agent mixing evenly, use 4 hours later, must replace the new ink, in order to appear dry nets, and curing agent solidification!B. may add 15% - 20% diluent to dilute as needed;C. construction parts to remove surface grease and dirt before construction;D. multicolor, should wait for the color table in front of dry color;E. should allow the ink layer completely dry when testing;D. shall not ink and other ink mixing and color matching, add curing agent, the effect will be greatly improved, if add curing agent, please ink in 4 hours run out.6, emergency treatment measures:A. if splashed to the eye, immediately clean water, serious medical treatment.B. fire emergency measures: use dry powder, foam extinguisher or sand to extinguish fire.Please note: due to the material and the use of variables that may be the result of a change, the above data for reference only, please test before use.